INSTALLATION INSTRUCTIONSAND OWNER'S MANUALUNVENTED GAS FIREPLACEMODELSHYDRAULIC MODELSVFP(32,36)BP2(0,1)L(N,P)-1MILLIVOLT MODELSVFP(32,36)BP3(
29898-8-1114Page 10Check all local codes for requirements, especially for the size and type of gas supply line required.RecommendedGasPipeDiameterP
29898-8-1114 Page 11MinimumWallandCeilingClearancesSidewall Clearances: The clearance from the inside of the replace to any combustible wall shou
29898-8-1114Page 12Do not attach combustible material to the mantel of your replace. This is a re hazard. Figure 6No greeting cards, stockings or or
29898-8-1114 Page 13CGAS LINEOPENINGJUNCTION BOXASSEMBLYGAS LINEOPENINGSTANDOFFBAIGHJDEVFP32BP VFP36BPA 34" 39"B 29" 34"C 17 3/8&q
29898-8-1114Page 14A black hood and trim kit is furnished with each model VFP(32,36)BP replace. The hood MUST be installed before the rep
29898-8-1114 Page 151. Place replace in framing opening.2. Using the four (4) nailing anges provided with the replace, attach two (2) anges
29898-8-1114Page 16RefertotheLogInstallationInstructionsforEmberplacement.Placement of the glowing embers (rock wool) is very individual and l
29898-8-1114 Page 17A. This appliance has a pilot which must be lighted byhand.Whenlightingthepilot,followtheseinstructionsexactly
29898-8-1114Page 181. Set thermostat (gas control knob) to lowest setting.2. Turn off all electric power to appliance if service is to be performe
29898-8-1114 Page 19TO TURN OFF GAS TO FIREPLACE1. STOP! Read the safety information above.2. Turn OFF electric power to the appliance.3. Remove fr
29898-8-1114Page 2SECTION PAGEWARRANTY ...
29898-8-1114Page 20Flames from the pilot (rear right back side of the pan burner) as well as the main ame should be visually checked as the log set i
29898-8-1114 Page 21Figures 13, 15 and 17 show a correct pilot ame pattern. The correct ame will be blue and will extend beyond the thermocouple. Th
29898-8-1114Page 22PILOT FLAME CHARACTERISTICSINTERMITTENT PILOTCorrectPilotFlamePatternPILOTSENSORIGNITORFigure 17IncorrectPilotFlamePatternPIL
29898-8-1114 Page 23Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Ve
29898-8-1114Page 24Ifthegasqualityisbad,yourpilotmaynotstaylit,theburnersmayproducesootandtheheatermaybackrewhenlit.Ifthega
29898-8-1114 Page 25INTERMITTENT CONTROL SYSTEM OPERATING INSTRUCTIONS5.25VDCELECTRONICCONTROLVALVEThe electronic control valve system includes th
29898-8-1114Page 26INTERMITTENT CONTROL SYSTEM WIRING DIAGRAMIf any of the original wire as supplied with this unit must be replaced, it must be repla
29898-8-1114 Page 27INTERMITTENT CONTROL SYSTEM TROUBLESHOOTINGBriefDescriptionoftheComponentsThe gas valve is equipped with a manual HI/LO knob t
29898-8-1114Page 28INTERMITTENT CONTROL SYSTEM TROUBLESHOOTING1If the DFC giving signal lock out: The board should be unlocked to reinitiate a pilot f
29898-8-1114 Page 29INTERMITTENT CONTROL SYSTEM TROUBLESHOOTING2Main burner lights when the pilot only should light.Pilot holds the flame?.Main burner
29898-8-1114 Page 3WARRANTYEmpire Comfort Systems Inc. warranties this hearth product to be free from defects at the time of purchase and for the peri
29898-8-1114Page 30FBB4BlowerInstallationAttention: Install blower assembly before connecting gas inlet supply line.Note: Junction box on right side
29898-8-1114 Page 31WiringThe appliance, when installed, must be electrically grounded in accordance with local codes or, in the absenc
29898-8-1114Page 32CAUTION: ALL WIRING SHOULD BE DONE BY A QUALIFIED ELECTRICIAN AND SHALL BE IN COMPLIANCE WITH ALL LOCAL, CITYANDSTATEBUILDINGCO
29898-8-1114 Page 33To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.com. To provid
29898-8-1114Page 34ATTENTION: When ordering parts, it is very important that part number and description of part coincide.VFP32BP(2,3,7) PARTS LISTInd
29898-8-1114 Page 35 USE ONLY MANUFACTURER'S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.NOTE: SEE LOG INSTRUCTION MANU
29898-8-1114Page 36ATTENTION: When ordering parts, it is very important that part number and description of part coincide.VFP36BP(2,3,7) PARTS LISTInd
29898-8-1114 Page 37ATTENTION: When ordering parts, it is very important that part number and description of part coincide.VFP36BP(2,3,7) PARTS LIST U
29898-8-1114Page 3812351617202320261617212225293013141518193132212223242827262567891112104MILLIVOLTVALVE ASSEMBLYHYDRAULICVALVE ASSEMBLYINTERMITTENT P
29898-8-1114 Page 39WARRANTYEmpire Comfort Systems Inc. warranties this hearth product to be free from defects at the time of purchase and for the per
29898-8-1114Page 4IMPORTANT SAFETY INFORMATIONDANGER: Indicates a hazardous situation which, if not avoided, will result in death or serious injury. W
29898-8-1114Page 40Empire Comfort Systems Inc.918 Freeburg Ave. Belleville, IL 62220If you have a general question about our products, please e-mail
29898-8-1114 Page 5Somepeoplecannotsmellwell.Somepeoplecannotsmelltheodorofthechemicalputintothegas.Youmustndoutifyoucansmel
29898-8-1114Page 6InstallationonRugsandTileIf this appliance is installed directly on carpeting, tile or other combustible material other than woo
29898-8-1114 Page 7Model VFP32BP VFP36BPInput Maximum 32,000 36,000Minimum 22,000 25,000MinimumFireboxOpeningHeight without standoff 32 3/4"
29898-8-1114Page 8Water vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for eve
29898-8-1114 Page 9The space in the above example is a conned space because the actual BTU/Hr used is more than the maximum BTU/HR the space can sup
Comments to this Manuals