Empire Comfort Systems VFP36PP32EP-2 Owner's Manual

INSTALLATION INSTRUCTIONSAND OWNER'S MANUALSEE-THROUGH FIREPLACE MODELS:VFP36SP32EN-1VFP36SP32EP-1PENINSULA FIREPLACE MODELS:VFP36PP32EN-1VFP36

24309-1-0908Page 10Check all local codes for requirements, especially for the size and type of gas supply line required.Note: Never use plastic pipe.

24309-1-0908 Page 11CLEARANCESFigure 4a - See Through Fireplace Clearances36”MIN.42”MIN.(CEILING TOTOP OF HOOD)1 3/4” MIN.PERPENDICULARCOMBUSTIBLESIDE

24309-1-0908Page 12CLEARANCES (cont.)Figure 6a - Mantel Clearances with Standard HoodFigure 6b - Mantel Clearances with Optional Extended HoodMANTELST

24309-1-0908 Page 13Fireplace FramingFraming can be built before or after the fireplace is set in place. Framing should be constructed to accommod

24309-1-0908Page 14Figure 10Fireplace DimensionsFIREPLACE INSTALLATION INSTRUCTIONS (continued)VFP36SP VFP36PPA34 3/4" 34 3/4"B39" 39&q

24309-1-0908 Page 15Locating FireplacePlace fireplace in framed opening. Attach the framing brackets to the fireplace and secure to framing. Different h

24309-1-0908Page 16Extended HoodsIf your non-combustible facing material is over 1" in thickness and will be used to finish this fireplace, extende

24309-1-0908 Page 17The fireplace is designed to accept a gas line for connection to the gas valve. Have the line installed by a qualified service pers

24309-1-0908Page 18Placement of the glowing embers (rockwool) is very individual and light coverage of the areas indicated will provide your best effe

24309-1-0908 Page 19Before you begin: Do not handle the logs with your bare hands! Always wear gloves to prevent skin irritation. After handling logs,

24309-1-0908Page 2TABLE OF CONTENTSCarton Contents ...

24309-1-0908Page 201. STOP! Read the safety information label.2. Open bottom louver assembly.3. Set REMOTE/OFF/ON switch to "OFF."4. Tur

24309-1-0908 Page 21Check the following items during installation prior to lighting the multisided burner:• Check all carryover ports for blockage fr

24309-1-0908Page 22Figure 16 show a correct pilot flame pattern. The correct flame will be blue and will extend beyond the thermocouple. The flame wi

24309-1-0908 Page 23Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation.

24309-1-0908Page 24If the gas quality is bad, your pilot may not stay lit, the burners may produce soot and the heater may backfire when lit. If the ga

24309-1-0908 Page 25WIRING INSTRUCTIONS FOR INSTALLING A DUAL SWITCH / RECEPTACLEIn order to install both the optional Blower and Accent Light ac-cess

24309-1-0908Page 26Attention: Install blower assembly before connecting gas in-let supply line.WiringThe appliance, when installed, must be electri

24309-1-0908 Page 274. Insert blower assembly into interior, bottom of firebox. Note: On peninsula models, the blower must be installed at the

24309-1-0908Page 28WiringThe appliance, when installed, must be electrically grounded in accordance with local codes or, in the absence of

24309-1-0908 Page 29MAINTENANCEKeep the control compartment, logs and burner area surround-ing the logs clean by vacuuming or brushing area at

24309-1-0908 Page 3CARTON CONTENTSFireplace AssemblyLava Rock PackageSoot Warning SheetInstallation Package Rockwool Packet Installation Instruction

24309-1-0908Page 30USE ONLY MANUFACTURER'S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.NOTE: SEE LOG INSTRUCTION MANUAL

24309-1-0908 Page 31Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order part

24309-1-0908Page 32SEE-THROUGH FIREPLACE PARTS VIEW146516891214456812149732242520171831414021232933301922342826NatGas363735274232383924254344454647442

24309-1-0908 Page 33PENINSULA FIREPLACE PARTS VIEW14568911101213141516812149732242520171831414021232933301922342826NatGas363735274232383924LP BURNER25

24309-1-0908Page 34Accessory Description Model NumbersFan Kit12Designed to provide forced air flow. FBB5Variable Speed Control KitWall mounted variab

24309-1-0908 Page 35Accessory Description Model NumbersAccent Light KitOptional light kit that installs in top of firebox to enhance logset. Operates w

24309-1-0908Page 36SERVICE NOTES

24309-1-0908 Page 37Web Site: www.empirecomfort.comThe Vail Premium Vent-Free FireplacesSEE-THROUGH FIREPLACE MODELS:VFP36SP32EN-1VFP36SP32EP-1PENINSU

24309-1-0908Page 38Web Site: www.empirecomfort.comThe Vail Premium Vent-Free FireplacesSEE-THROUGH FIREPLACE MODELS: PENINSULA FIREPLACE MODELS:VFP36S

24309-1-0908 Page 39Premium Vent-Free Fireplace Framing Dimensions (inches)"A" "B" "C"*Model Framing Height Framing Widt

24309-1-0908Page 4When used without adequate combustion and ventilation air, heater may give off CARBON MONOXIDE, an odorless, poi-sonous gas. Do not

24309-1-0908Page 40EMPIREEMPIREComfort SystemsEmpire Comfort Systems Inc.918 Freeburg Ave. Belleville, IL 62220If you have a general question about o

24309-1-0908 Page 5Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. You must find out if you can smel

24309-1-0908Page 6Installation on Rugs and TileIf this appliance is installed directly on carpeting, tile or other combustible material othe

24309-1-0908 Page 7ModelVFP36(SP,PP)32EN (NAT) VFP36(SP,PP)32EP (LP)Input Maximum 38,000 38,000Minimum 25,000 30,000Overall DimensionsHeight without

24309-1-0908Page 8Water vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for eve

24309-1-0908 Page 9The space in the above example is a confined space because the actual BTU/Hr used is more than the maximum BTU/HR the space can supp