INSTALLATION INSTRUCTIONSAND OWNER'S MANUALOUTDOOR GAS FIREPLACEMODELSOP36FP32M(N,P)-1OP36FP72M(N,P)-1OP42FP32M(N,P)-1OP42FP72M(N,P)-1Outdoor Gas
27777-8-0413Page 10FIREPLACE DIMENSIONSREFERENCE LETTER OP36FP OP42FPA 37 5/8" 37 5/8"B 39 1/2" 43 1/2"C 19 13/16" 19 13/16&q
27777-8-0413 Page 11In planning the installation for the replace, it is necessary to determine where the unit is to be installed and whethe
27777-8-0413Page 121. Place replace in framing opening.2. Using the four (4) nailing anges provided with the replace, attach two (2) anges o
27777-8-0413 Page 13Flames from the pilot (rear right back side of the pan burner) as well as the main ame should be visually checked as the log set
27777-8-0413Page 14FOR YOUR SAFETY READ BEFORE LIGHTINGWARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSIN
27777-8-0413 Page 151. STOP! Read the safety information above.2. Set the ON/OFF switch to "OFF."3. Turn off all electric power to the ap
27777-8-0413Page 16Pilot Flame Pattern Figure 10 shows a correct pilot ame pattern. The correct ame will be blue and will extend beyond the thermoco
27777-8-0413 Page 17Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify p
27777-8-0413Page 18WIRINGMAINPILOTLearnMOTOR COMM.POWERIPIContinuousPilotOff/OnRemote/OffS IADJ.(GND)HI/LOSolenoidORANGE(IGNITOR)BLACK(SENSOR)BLACKORA
27777-8-0413 Page 19TWO-FUNCTION WIRELESS REMOTE CONTROL SYSTEMFOR ON/OFF-HI/LO OPERATION OF THE AF-4000 GAS CONTROL VALVEIF YOU CANNOT READ OR UNDERS
27777-8-0413Page 2SECTION PAGEImportant Safety Information ...3Safety
27777-8-0413Page 20Keep the control compartment, logs and burner area surrounding the logs clean by vacuuming or brushing area at least twice a year.T
27777-8-0413 Page 21To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.com. To provid
27777-8-0413Page 22PARTS LISTIndex No.PART No.DescriptionOP36FP32 OP36FP72 OP42FP32 OP42FP721 17247 17247 17247 17247 Top Standoff2 27781 27781 27782
27777-8-0413 Page 23PARTS VIEW29313010865112213131433891174333635182120191622281517253415162317262722283421201925182432
27777-8-0413Page 24EMPIREEMPIREComfort SystemsEmpire Comfort Systems Inc.918 Freeburg Ave. Belleville, IL 62220If you have a general question about o
27777-8-0413 Page 3 Installer: Please leave these instructions with the owner for future reference This unit complies with ANSI Z21.97/CSA 2.41 an
27777-8-0413Page 4Some people cannot smell well. Some people cannot smell the can smell
27777-8-0413 Page 5Hearths should slope away from the front of the replace and chase at 1/8 in to 1/4 in per foot. Metal safety strips must be on top
27777-8-0413Page 6INTRODUCTION• When the appliance is connected to a xed piping system, the installation must conform with local codes, or in the ab
27777-8-0413 Page 7Model OP36FP OP42FPInput Maximum 40,000 50,000Minimum 36,000 LP / 38,000 NAT 36,000 LP / 38,000 NATOrice P245 #50 LP / P209 #31
27777-8-0413Page 8Minimum Wall and Ceiling Clearances (Figure 2)Sidewall and Back Clearances: The clearance from the inside of the replace to any com
27777-8-0413 Page 9Do not attach combustible material to the mantel of your replace. This is a re hazard.Figure 3No greeting cards, stockings or orn
Comments to this Manuals